Skip to content
MotorFiable
en

Engine

Problems with the fuel pump: symptoms, cost and affected models

We have documented 28 faults with the fuel pump in 27 engines, affecting 214 models of car in our database. The most important by severity and frequency: low-pressure fuel pump failure: loss of power and fire risk (2.0 and 2.5 Hybrid), high-pressure fuel pump (HPFP) failure (BMW N54/N55, BMW N13 and BMW N20) and injection pump or injector failure (2.2/2.5 dCi). At an independent garage, the repair costs from €250 to €2,000 depending on the engine or car.[1][2]

Documented faults
28
18 of high or critical severity
Engines
27
with at least one fault on this part
Affected models
214
car generations in our database
Garage repair
€250–€2,000
Depending on engine and car, including VAT

6 sourcesHow we work

How it works and why it fails

Fuel pump and high-pressure pump

The low-pressure pump brings fuel from the tank and the high-pressure pump compresses it for the injectors. On common rail diesels, a high-pressure pump that wears out can shed metal particles and contaminate the entire injection system, which multiplies the cost.

What to do

Hard starting, loss of power, stalling or the car cutting out while driving are the usual warnings. Fill up at trusted stations and change the fuel filter on time. If the pump has shed particles, the workshop must also clean or replace the injectors and the pipes.

General explanation by MotorFiable. The specific faults of each engine and car, with their sources, are on the linked pages.

Common symptoms

The symptoms that come up most often in the documented faults with the fuel pump. Open each one to see what other faults cause it.

Problems with the fuel pump by engine

From most to least important (severity × frequency). Each page details the affected versions and years, symptoms, cost and how to check for it.

  1. 1Critical severityFrequency: Common2.0 and 2.5 HybridLow-pressure fuel pump failure: loss of power and fire riskYes: a low-pressure fuel pump with a defective impeller (Denso) affects millions of Toyotas and Lexuses, including Corolla, C-HR, RAV4 and Camry models with these engines. It can cause loss of power or stalling, and in the EU there is also a risk of leaks and fire on 2018-2022 Corolla, C-HR and Auris models.
  2. 2High severityFrequency: CommonBMW N54/N55High-pressure fuel pump (HPFP) failureThe N54's high-pressure pump is one of its best-documented failures: most units will have had it replaced at some point. It warns of itself with long cranking and loss of power; the 2010 campaign was US-only.
  3. 3High severityFrequency: Common2.2/2.5 dCiInjection pump or injector failureThe 2.2 dCi's common rail injectors fail fairly often on the X-Trail and Almera, with cases of seizing and leaks; on the Almera with the older YD22DDT, the documented fault is in the injection pump electronics, not the injectors.
  4. 4High severityFrequency: CommonVW 2.0 TFSI EA113Wear of the high-pressure pump cam followerYes: the 2.0 TFSI EA113's high-pressure fuel pump is driven by the camshaft through a follower (tappet) that wears; if it wears through it can damage the pump or the camshaft, so it should be checked and replaced as a preventive measure.Repair (garage): €250–€900Appears at around 90,000 km
  5. 5Critical severityFrequency: Occasional1.8 TDCiBreakage of the timing belt or of the high-pressure pump's belt (running in oil)Yes: the 1.8 TDCi combines a dry belt for the camshafts with a second belt, running in oil, that drives only the Delphi high-pressure pump. If the tensioner fails or replacement is neglected, the engine can cut out suddenly or suffer serious internal damage.Appears at around 110,000 km
  6. 6High severityFrequency: Occasional1.5 BlueHDiSeizure of the high-pressure pump and injection systemSome early 1.5 BlueHDi engines have suffered seizure of the Bosch high-pressure pump, with juddering or the engine stalling on the road, sometimes before 50,000 km. The repair means replacing the entire injection system and the fuel tank.
  7. 7High severityFrequency: Occasional2.0 TDIHigh-pressure pump, injectors and diesel leaks on the EA189On the 2.0 TDI EA189, the high-pressure pump can shed metal particles that force the pump and injectors to be replaced. In addition, 2009-2011 units were recalled for diesel leaks from the high-pressure pipes.
  8. 8High severityFrequency: Occasional1.5 dCiDelphi high-pressure pump that sheds filings and damages the injectionOn the first 1.5 dCi engines (up to approx. 2010), especially the versions with Delphi injection of 65, 70 and 85 hp, the high-pressure pump can shed iron filings that contaminate the whole circuit and destroy the injectors. The pump, injectors and rail all have to be replaced.Appears at around 60,000 km
  9. 9High severityFrequency: Occasional1.3 MultijetInjector and high-pressure pump wear from contaminated fuelThe Bosch injectors and the high-pressure pump of the common rail system are sensitive to poor-quality fuel or fuel with condensed water. With contaminated diesel they can generate metal shavings that damage first the pump and then the injectors themselves.Repair (garage): €600–€1,200
  10. 10High severityFrequency: Occasional1.3 TCeBlown fuel pump fuseOn the Renault Captur II and Clio V with the 1.3 TCe engine, a 20-amp fuse can blow and leave the car without an engine. According to L'argus, in April 2021 this fault still had no factory fix; the official service centre's diagnosis includes checking, and sometimes replacing, the catalytic converter.
  11. 11High severityFrequency: Occasional1.0 / 1.5 VTEC TurboDefective impeller in the fuel pump (Honda 6FE recall, Civic, CR-V and HR-V 2017-2020)Honda recalled several models built between September 2017 and March 2020 in Europe, including the Civic X, CR-V V and HR-V, because the fuel pump impeller could crack and cause the engine to stall or fail to start. It is corrected by replacing the pump.
  12. 12High severityFrequency: OccasionalHonda e:HEV / i-MMDCracked high-pressure fuel pump (Honda campaign 6YP)Honda recalled around 1.38 million Civic, CR-V and ZR-V cars built between 2021 and 2024 in Europe because the high-pressure fuel pump could crack, causing a fuel leak and a risk of fire. In France it was later extended to 4,740 hybrids.
  13. 13High severityFrequency: OccasionalHonda e:HEV / i-MMDFaulty fuel pump impeller on the 2019-2020 CR-V hybrid (Honda 6FE campaign)The Honda 6FE campaign (Safety Gate 29/2024) covers the CR-V hybrid (types RT5 and RT6) built between 2017 and 2020, because of a fuel pump impeller that could crack and cause stalling or a failure to start. The fix is to replace the pump.
  14. 14High severityFrequency: Occasional1.7 CRDiHigh-pressure fuel pump failureThe common rail system's high-pressure pump can fail at around 80,000-100,000 km, with hard cold starts, an uneven idle and power loss; if ignored, there is a risk of metal debris contaminating the rest of the injection system.Repair (garage): €650–€2,000Appears at around 80,000 km
  15. 15High severityFrequency: Occasional2.0 DTI and 2.2 DTIVP44 injection pump and air mass meter failureGerman Wikipedia documents recurring failures of the Bosch VP44 injection pump and the air mass meter in the early years of this engine. An owner testimony for this engine describes the pump being replaced at 192,500 km, at a cost the owner calls «prohibitive».
  16. 16High severityFrequency: Occasional2.0 BlueHDiInjector and high-pressure pump wearThe injectors and the high-pressure pump on the 2.0 BlueHDi are among the documented faults, although in a minority of the cases recorded compared with AdBlue or the DPF. When the pump fails, metal particles can contaminate the whole circuit and make the repair far more expensive.
  17. 17High severityFrequency: Occasional1.2 TDITiming belt, water pump and high-pressure pumpOn this engine, a single toothed belt drives the camshaft, the water pump and the common-rail high-pressure pump. If the water pump seizes, it can drag the belt with it and cause it to jump a tooth or break, with the risk of serious engine damage.Repair (garage): €400–€700
  18. 18Medium severityFrequency: Common1.6 THPHigh-pressure fuel pump (HPFP) failure on the turbo versionsThe high-pressure pump that feeds the direct injection of the turbo (THP) versions can fail. MINI, which uses the same block in the Cooper S, extended the warranty on this part in 2010 to 10 years or 192,000 km for 2007-2009 models in the US, without the need for a recall.
  19. 19Medium severityFrequency: OccasionalBMW N13High-pressure fuel pump (HPFP) failureThe high-pressure pump that feeds the N13's direct injection can fail. English Wikipedia generically documents several cases of extended-warranty replacement within the Prince family, with no specific figures or N13-specific recall.
  20. 20Medium severityFrequency: OccasionalBMW N20High-pressure fuel pump (HPFP) failureThe high-pressure pump that feeds the N20's direct injection (High Precision Injection) can fail, especially on high-mileage units, leaving the car with hard starting, jerking or, in the worst case, unable to start.
  21. 21Medium severityFrequency: OccasionalSkyactiv-GMicro-cracks in the fuel pump impellerBetween October 2017 and May 2020, Mazda built Mazda3 and CX-5 units with a fuel pump whose impeller can crack, swell and end up cutting off the fuel supply with the engine running; the manufacturer recalled the affected cars.
  22. 22Medium severityFrequency: Occasional1.5 K15B (Jimny)Fuel pump with resin impeller that swells (recall)Jimnys from 2018 to 2020 were recalled because the resin impeller of the fuel pump could swell and deform. It is a precautionary recall, and the German source itself says the problem was mostly corrected.
  23. 23Medium severityFrequency: OccasionalVM Motori 2.8 and 3.0 CRDWear of the injectors and the high-pressure pumpThe injectors and common-rail pump of the 2.8 and the 3.0 V6 CRD can wear with the years: the sources place it between 120,000 and 180,000 km and describe it as loss of power or limp mode, not a widespread failure.Repair (garage): €800–€1,400Appears at around 120,000 km
  24. 24High severityFrequency: RareMIVEC gasolinaCracked fuel pump cover with fuel leak on the ColtOn the 2010-2011 Colt the cover of the fuel pump unit could crack and let vapour or fuel escape from the tank; there was a recall: 64 cars in the United Kingdom according to the DVSA and about 1,348 according to Gebrauchtwagenberater, which speaks of the tank sender unit.
  25. 25Medium severityFrequency: Rare1.6 EcoBoostHigh-pressure fuel pump failureThere is at least one documented case of high-pressure fuel pump failure in a Ford Mondeo, at 82,500 km and already outside the 5-year warranty; we have found no further cases suggesting it is a widespread fault in this engine.
  26. 26Medium severityFrequency: Rare1.6 16v HR16DE / H4MIsolated case of engine stalling due to the fuel pumpOne account from the Nissan Note (first generation) with this engine describes the car stalling while driving because of a fuel pump failure. It is an isolated case among the accounts consulted, not a repeated pattern.
  27. 27Medium severityFrequency: Rare1.0 TCe / SCeFailed high-pressure fuel pump (isolated case)Fiches-auto.fr documents one case of a failed high-pressure fuel pump on a Nissan Juke II with the 1.0 DIG-T at 18,000 km, leaving the car immobilised. The source itself states that it sees no general trend.
  28. 28Low severityFrequency: Rare1.0 and 1.4 BoosterjetDirect injection and fuel pump: no documented faults or recallsWe have not found any recall or pattern of failures of the high-pressure pump or injectors on the 1.0 or the 1.4 Boosterjet, unlike other small direct-injection turbo engines from other manufacturers.

Engines with faults with the fuel pump

Fuel pump and high-pressure pump: compare prices in shops

Search for the part using the make, model and engine of your car: in the shop, the registration plate or VIN filters the parts that fit.

Affiliate links: if you buy from these shops, MotorFiable may receive a commission at no cost to you. Check compatibility against the registration plate or VIN before ordering. More information

Problems with the fuel pump by make

Problems with the fuel pump in your car

26 cars have several documented faults with the fuel pump. Choose yours to see only the ones that affect them, by engine and by year.

Audi 1
BMW 3
Citroën 2
DS 1
Ford 3
Honda 1
Nissan 3
Opel 3
Peugeot 6
Seat 1
Škoda 1
Volkswagen 1

How much it costs to repair a fault with the fuel pump

Sorted from the most expensive repair to the cheapest. Prices in Spain including VAT (parts and labour); what each figure includes is on its page.

How we calculate costs · The most expensive repairs across all engines

OBD fault codes with the fuel pump

The codes the ECU usually stores when this part fails: what they mean, causes and what to check.

Frequently asked questions

Which engines have the most faults with the fuel pump?

By severity and frequency, the 2.0 and 2.5 Hybrid (low-pressure fuel pump failure: loss of power and fire risk, critical severity), the BMW N54/N55 (high-pressure fuel pump (HPFP) failure, high severity), the 2.2/2.5 dCi (injection pump or injector failure, high severity), the VW 2.0 TFSI EA113 (wear of the high-pressure pump cam follower, high severity), the 1.8 TDCi (breakage of the timing belt or of the high-pressure pump's belt (running in oil), critical severity) and the Honda e:HEV / i-MMD (cracked high-pressure fuel pump (Honda campaign 6YP), high severity). In total we have documented 27 engines with faults with the fuel pump.

How much does it cost to repair a fault with the fuel pump?

It depends a lot on the engine or car. At an independent garage, from €250 to €2,000, including VAT, based on the 5 faults with a documented cost. The most expensive is high-pressure fuel pump failure (1.7 CRDi).

What symptoms does a fault with the fuel pump cause?

The most frequently cited in the documented faults: engine stalls or cuts out while driving, hard starting or engine will not start, gradual loss of power, engine fault warning light (check engine), jerking or juddering when accelerating and smell of fuel.

Sources

Every fact on this page links to its source. If you find an error, let us know.

  1. 2.0 TFSI (EA113): problemas conocidosAutoscore · Other source · consulted 5 October 2026
  2. Hyundai iX35 1.7 Crdi Problemas | Fallos y averías más frecuentesTotalRenting · Other source · consulted 27 September 2026 · in Spanish
  3. Problemas Jeep Wrangler 2.8 CRDTotal Renting · Other source · consulted 8 October 2026 · in Spanish
  4. Problemas Jeep Grand Cherokee 3.0 CRDTotal Renting · Other source · consulted 8 October 2026 · in Spanish
  5. Fiat 1.3 Multijet: problemas, fallos y averías más frecuentesTotalrenting · Other source · consulted 26 September 2026 · in Spanish
  6. Bomba de agua del coche: la avería de más de 1.500 euros que arrastra la correa de distribuciónMotor16 · Motoring press · published 21 September 2026 · consulted 27 September 2026 · in Spanish